September 25, 2021, 02:50:25 PM

Author Topic:  15 Interceptor Sedan Ecoboost with GHT Tune - Engine Coolant Overtemp  (Read 3388 times)

Offline TonytheBrit

  • Newbie
  • *
  • Thank You
  • -Given: 0
  • -Received: 0
  • Posts: 1
  • Ecobooster
  • Liked:
  • Likes Given: 0
I installed a basic 93 octane tune from GHTuning on my 15 Interceptor Sedan Ecoboost.  I love the tune - the power is noticeably up but the biggest improvement is the transmission which no longer seems 3 steps behind.  Of course the Interceptors don't have Sport Mode so this is more important with one of these.

My issue is that 3 laps out on Gingerman Raceway I'm getting an Engine Coolant Overtemp warning and code.  No other codes.  The cooling system seems OK and it has only happened on the track.  Anyone have any experience of this?  I could replace the temp sensor but it is a big job so I'm reluctant.  The digital temp gauge showed normal the whole time - but that doesn't move unless you are pretty much boiling I believe so may not mean anything.

If I do need to upgrade the cooling do you have any practical suggestions?

Offline Macgyver

  • Super Moderator
  • Elite Member
  • *
  • *
  • Reading, Pa.......
  • Thank You
  • -Given: 100
  • -Received: 388
  • Posts: 992
  • Ecobooster
  • Liked:
  • Likes Given: 28
Tracking it puts a strain on the system for sure. You are really tracking it. Not just a drag strip. I would make sure the coolant is topped off. Maybe install 160/170 thermostats even tho they will be open and stay open on the track no matter what the stat temp is.

I would monitor the "true" coolant temp next time via the programmer or laptop and programmer and see if it is actually getting that hot to set it off.

Also. Make sure your engine oil is topped off all the way to max. Its not a dry sump racing system. I am no expert but I would hate to starve the motor in a hard braking corner because the oil sloshes to one side ? Not sure if they are prone to this or not.

Lastly. Maybe the GHT has the default temp lowered a bit for safeties sake?
« Last Edit: July 16, 2021, 01:24:02 PM by Macgyver »

Offline Ta2dResqr

  • Jr. Member
  • *
  • Central Ohio
  • Thank You
  • -Given: 0
  • -Received: 8
  • Posts: 29
  • Newb
  • Liked:
  • Likes Given: 37
When was the last time coolant was changed? It does break down over time. You may also want to consider a coolant additive (such as Water Wetter, Purple Ice, etc). Installing a lower temperature thermostat or adjusting fan temps (within the tune) may help. Lastly, I would start looking at methods to contain or eliminate heat. Wrapping exhaust components or coolant pipes to lower underhood temperatures. Adding hood vents (true functional products). Methanol injection. Adding trans or PTU coolers. Everywhere you can lower temp will lower over all heat and allow the system to last longer before you have issues.
Alicia "Sugar Bumps" Hunt 2015 White Platinum Tri-coat Metallic, Livernois Windstorm Cold Air Intake, Livernois Performance Springs, Possible Tune? (3 Bar MAP), MSD Ignition Coils, Drive Bright Puddle Lights, Drive Bright License Plate Lights, FORScan

Offline SHOdded

  • Forum Supporters
  • Elite Member
  • *
  • Beltsville, MD
  • Thank You
  • -Given: 13057
  • -Received: 4249
  • Posts: 15953
  • Liked:
  • Likes Given: 54
on the 2.7, ford says to replace the ECT sensor and/or the knock sensor harness. how do the knock readings look in your datalog.
2007 Ford Edge SEL, Powerstop F/R Brake Kit, TXT LED 6000K Lo & Hi Beams, W16W LED Reverse Bulbs, 3BSpec 2.5w Map Lights, 5W Cree rear dome lights, 5W Cree cargo light, DTBL LED Taillights

If tuned:  Take note of the strategy code as you return to stock (including 3 bar MAP to 2 bar MAP) -> take car in & get it serviced -> check strategy code when you get car back -> have tuner update your tune if the strategy code has changed -> reload tune -> ENJOY!


* Recent Topics

Re: Updating SYNC with new maps and new highway exit numbers
by Peetah75 | Today at 07:19:46 AM
Hi Ta2dResqr,  Just saw your reply.  You are correct, that ...
Re: Terrain Management System Fault - wrench light
by EcoHell | September 24, 2021, 08:17:28 PM
All I can do is laugh at my predicament on the low voltage issue menti...
Re: Intermittent stutter under load
by bubbarotondo21 | September 24, 2021, 08:10:42 PM
any codes?  please post at least one representative datalog for f...
Re: SHO low fuel pressure help
by ridered74 | September 24, 2021, 11:13:01 AM
Maybe the fuel pressure sensor that is under the intake manifold? I�...
Re: Is this the proper adapter?
by LMKS012 | September 23, 2021, 07:43:28 PM
Now, I *COULD* just get an extra master cylinder cap and cut a hole fo...
Re: HID preference
by Ta2dResqr | September 23, 2021, 03:21:43 PM
Hey, did you ever upgrade your HID's?I have a 2016 as well .... b...
Re: Speedometer stopped working/not shifting
by SHOdded | September 23, 2021, 02:58:00 PM
how many miles on your SHO?would check the connectors at the solenoid ...
Re: My new ST
by SHOdded | September 23, 2021, 02:41:14 PM
Re: 2015 Fusion 2.0
by SHOdded | September 23, 2021, 02:40:39 PM
p0012 is more likely something to do with timing. whether it is VCT so...
Re: PTU going bad
by SHOdded | September 23, 2021, 02:31:01 PM
how goes it?removing the driveshaft is possible and safe.  it wil...

SimplePortal 2.3.5 © 2008-2012, SimplePortal