June 23, 2021, 04:46:59 PM
collapse
collapse

Author Topic:  All at once fueling issues  (Read 549 times)

Offline EvoSHO

  • Newbie
  • *
  • Thank You
  • -Given: 0
  • -Received: 1
  • Posts: 6
  • Ecobooster
  • Liked:
  • Likes Given: 3
All at once fueling issues
« on: June 04, 2021, 08:54:35 AM »
So 2013 SHO 91K miles, unleashed tune, 3 bar, intake, no cats DPs. 
Car had sudden misfire.  Dealer diagnosed fuel pressure sensor at rail.  Fixed and car drove fine for a month.  Then same miss and white smoke.  Checked the smoke and smelled strongly of fuel.  Went ahead and replaced fuel pressure sensor at tank, replaced ALL injectors with brand new units, new plugs, fresh oil change.

Car turned but no fire.  ONLY code showing is P00C6 that states:
If the high-pressure fuel system cannot achieve this threshold within a certain time and crankshaft rotation limits, the Powertrain Control Module (PCM) attempts to start the engine at fuel pump module pressure and sets the Diagnostic Trouble Code (DTC) P00C6.

Only thing I can think of the damn HPFP crapped itself.  I have ordered a new unit.

Any other possible insight?

Offline shoryde

  • Jr. Member
  • *
  • Cincinnati
  • Thank You
  • -Given: 11
  • -Received: 0
  • Posts: 17
  • Ecoboosted
  • Liked:
  • Likes Given: 1
Re: All at once fueling issues
« Reply #1 on: June 04, 2021, 11:05:30 AM »
Check all the plugs and connections from replacing the injectors. There are a lot of plugs up there that might not be fully seated 100%. I am running into a similar misfire only at WOT. Can you explain the misfire you are also seeing? Only in high RPM? Higher boost?


FYI, I am running DW 1700 injectors and was having Unleashed tune my system as well and he said it was not clear as to why I was getting misfires at wot. It looked ignition related. This weekend I am taking it 100% back to stock with a knock off set of injectors to see if they are the cause of my misfire. Apparently DW injectors have been an issue with some people.

Offline EvoSHO

  • Newbie
  • *
  • Thank You
  • -Given: 0
  • -Received: 1
  • Posts: 6
  • Ecobooster
  • Liked:
  • Likes Given: 3
Re: All at once fueling issues
« Reply #2 on: June 04, 2021, 11:43:56 AM »
Check all the plugs and connections from replacing the injectors. There are a lot of plugs up there that might not be fully seated 100%. I am running into a similar misfire only at WOT. Can you explain the misfire you are also seeing? Only in high RPM? Higher boost?


FYI, I am running DW 1700 injectors and was having Unleashed tune my system as well and he said it was not clear as to why I was getting misfires at wot. It looked ignition related. This weekend I am taking it 100% back to stock with a knock off set of injectors to see if they are the cause of my misfire. Apparently DW injectors have been an issue with some people.

Checked all connections across the board and even replaced fuel pump control module. 
My misfire was at low RPMs specifically at idle

Offline Macgyver

  • Super Moderator
  • Elite Member
  • *
  • *
  • Reading, Pa.......
  • Thank You
  • -Given: 100
  • -Received: 387
  • Posts: 963
  • Ecobooster
  • Liked:
  • Likes Given: 23
Re: All at once fueling issues
« Reply #3 on: June 04, 2021, 03:39:19 PM »
So 2013 SHO 91K miles, unleashed tune, 3 bar, intake, no cats DPs. 
Car had sudden misfire.  Dealer diagnosed fuel pressure sensor at rail.  Fixed and car drove fine for a month.  Then same miss and white smoke.  Checked the smoke and smelled strongly of fuel.  Went ahead and replaced fuel pressure sensor at tank, replaced ALL injectors with brand new units, new plugs, fresh oil change.

Car turned but no fire.  ONLY code showing is P00C6 that states:
If the high-pressure fuel system cannot achieve this threshold within a certain time and crankshaft rotation limits, the Powertrain Control Module (PCM) attempts to start the engine at fuel pump module pressure and sets the Diagnostic Trouble Code (DTC) P00C6.

Only thing I can think of the damn HPFP crapped itself.  I have ordered a new unit.

Any other possible insight?

Cheap part to throw at it would be the LPFP relay. It is behind the passenger rear seatback carpet fire wall area.

Offline EvoSHO

  • Newbie
  • *
  • Thank You
  • -Given: 0
  • -Received: 1
  • Posts: 6
  • Ecobooster
  • Liked:
  • Likes Given: 3
Re: All at once fueling issues
« Reply #4 on: June 04, 2021, 10:01:39 PM »
So 2013 SHO 91K miles, unleashed tune, 3 bar, intake, no cats DPs. 
Car had sudden misfire.  Dealer diagnosed fuel pressure sensor at rail.  Fixed and car drove fine for a month.  Then same miss and white smoke.  Checked the smoke and smelled strongly of fuel.  Went ahead and replaced fuel pressure sensor at tank, replaced ALL injectors with brand new units, new plugs, fresh oil change.

Car turned but no fire.  ONLY code showing is P00C6 that states:
If the high-pressure fuel system cannot achieve this threshold within a certain time and crankshaft rotation limits, the Powertrain Control Module (PCM) attempts to start the engine at fuel pump module pressure and sets the Diagnostic Trouble Code (DTC) P00C6.

Only thing I can think of the damn HPFP crapped itself.  I have ordered a new unit.

Any other possible insight?

Cheap part to throw at it would be the LPFP relay. It is behind the passenger rear seatback carpet fire wall area.

Yep did that as well

Offline shoryde

  • Jr. Member
  • *
  • Cincinnati
  • Thank You
  • -Given: 11
  • -Received: 0
  • Posts: 17
  • Ecoboosted
  • Liked:
  • Likes Given: 1
Re: All at once fueling issues
« Reply #5 on: June 04, 2021, 11:47:12 PM »
Fuses all good?

Offline EvoSHO

  • Newbie
  • *
  • Thank You
  • -Given: 0
  • -Received: 1
  • Posts: 6
  • Ecobooster
  • Liked:
  • Likes Given: 3
Re: All at once fueling issues
« Reply #6 on: June 05, 2021, 07:05:14 PM »
Fuses all good?
Did not think to check that anything in particular I should be looking for?

 

* Recent Topics

Re: Verdict : Torrington bearing on the way out.
by TopherSho | Today at 02:24:46 PM
*final update on this thread*Finally figured out what made the last tr...
Re: Datalogging with SCTx4 Device
by ridered74 | Today at 12:23:20 AM
Thanks for this amazing write up. I'll be doing this today to sen...
Re: What have you done to your Ecoboosted vehicle today?
by Scott13SHO | June 21, 2021, 08:03:06 PM
I sold my SHO today to Carvana.Why Carvana ?Why not? I havenít been dr...
Re: PPE catted downpipes missing 02 sensor bung
by Macgyver | June 20, 2021, 12:05:51 PM
Wow, the price has really gone up... but so has everything else.Had tw...
Re: "Complete" List of TSB's for your 2010-2012 SHO
by rdmccrary | June 18, 2021, 08:55:54 AM
TSB 10-22-4 AWD VEHICLES - SHUDDER-CHATTER-VIBRATION ON TURNS OR THUMP...
Re: Picked up an 18 Navigator
by jims2015 | June 18, 2021, 08:46:52 AM
So you dont get the $7500 off the sticker then ?Nope, you take it off ...
Re: Factory fuel pump specs
by Macgyver | June 17, 2021, 08:17:35 PM
Yeah but then you should need a LPFP to feed it and will it run off th...
Re: RockAuto.com Discount Code - Expires July 5, 2021
by Broodingrage | June 16, 2021, 07:33:54 AM
This vendor saved my wallet when I had to replace my 2013 MKS Dynamic ...
Re: Engine Fans start immediately Mks
by Matt_Sommers | June 15, 2021, 07:59:40 PM
Is the AC on? If yes, then the fans are supposed to be running.I didn&...
Re: 2010 ford sho blue smoke on decel
by 6500rpm | June 15, 2021, 04:37:07 PM
I  just ran my car in Oasis last week and was reading through TSB...

SimplePortal 2.3.5 © 2008-2012, SimplePortal